Comfort Flame CCL3930PRA Installation Manual

Save this manual for future reference.For more information, visit www.desatech.comWARNING: If the information in this manual is notfollowed exactly, a

www.desatech.com 111161-01D10INSTALLATIONContinuedFigure 5 - Heat Resistant Material (Slate,Marble, Tile, etc.) Above FireplaceIf Using MantelYou must

www.desatech.com111161-01D 11MinimumNoncombustible Material 8"Min.12" 15" 18"All minimum distances arein inchesLog Set18", 24

www.desatech.com 111161-01D12INSTALLING HEATER BASEASSEMBLY CAUTION: Do not removethe data plates attached to theheater base assembly. The dataplates

www.desatech.com111161-01D 13For propane/LP units, the installer must supply anexternal regulator. The external regulator will re-duce incoming gas pr

www.desatech.com 111161-01D14INSTALLATIONContinued* Purchase the optional CSA design-certifiedequipment shutoff valve from your dealer. SeeAccessories

www.desatech.com111161-01D 15INSTALLATIONContinuedTest Pressures Equal To or Less Than1/2 PSIG (3.5 kPa)1. Close equipment shutoff valve (see Figure 1

www.desatech.com 111161-01D16INSTALLING WIRELESS HAND-HELD REMOTE CONTROLACCESSORYTwo 9-volt alkaline batteries (not included) arerequired to operate

www.desatech.com111161-01D 17INSTALLATIONContinuedINSTALLING LOGS WARNING: Failure to posi-tion the parts in accordance withthese diagrams or failure

www.desatech.com 111161-01D185. Locate pegs on the bottom of crossover log(#5). Slide these pegs into the holes locatedin crossover log (#4) and front

www.desatech.com111161-01D 19OPERATING HEATERFOR YOUR SAFETYREAD BEFORE LIGHTING WARNING: If you do not fol-low these instructions exactly,a fire or e

www.desatech.com 111161-01D2WARNING: Improper installation, adjustment, altera-tion, service, or maintenance can cause injury or prop-erty damage. Ref

www.desatech.com 111161-01D20 CAUTION: Do not try to ad-just heating levels by using theequipment shutoff valve. WARNING: Make sure theselector switch

www.desatech.com111161-01D 21MANUAL LIGHTINGPROCEDURE1. Follow steps 1 through 6 under Lighting In-structions, pages 19 and 20.2. Depress control knob

www.desatech.com 111161-01D22OPERATING HEATERContinuedManual Mode1. Press the POWER and LOCK buttons to-gether to turn on the hand-held remotecontrol.

www.desatech.com111161-01D 23CLEANING ANDMAINTENANCE WARNING: Turn off heaterand let cool before cleaning. CAUTION: You must keepcontrol areas, burner

www.desatech.com 111161-01D24TROUBLESHOOTING WARNING: Turn off heater and let cool before servicing. Only aqualified service person should service and

www.desatech.com111161-01D 25POSSIBLE CAUSE1.Control knob not fully pressed in2. Control knob not pressed inlong enough3. Equipment shutoff valve notf

www.desatech.com 111161-01D26POSSIBLE CAUSE1. Not enough air2. Gas regulator defective3. Residues from manufacturingprocesses and logs curing1. Not en

www.desatech.com111161-01D 27POSSIBLE CAUSE1. Heater burning vapors frompaint, hair spray, glues, clean-ers, chemicals, new carpet, etc.(See IMPORTANT

www.desatech.com 111161-01D28ILLUSTRATED PARTS BREAKDOWNMODELS CCL3018PR, CCL3018PRA, CCL3018NR, AND CCL3018NRA923252423211211144512181013302263820715

www.desatech.com111161-01D 29PARTS LISTThis list contains replaceable parts used in your heater. When ordering parts, follow the instructionslisted un

www.desatech.com111161-01D 3SAFETY INFORMATION WARNING: This product con-tains and/or generates chemicalsknown to the state of Californiato cause canc

www.desatech.com 111161-01D3030181927182312111445121710212022673920168152928282526OFFPILOTONHILOOFFPILOTONHILO243113ILLUSTRATED PARTS BREAKDOWNMODELSC

www.desatech.com111161-01D 31PARTS LISTThis list contains replaceable parts used in your heater. When ordering parts, follow the instructionslisted un

www.desatech.com 111161-01D32SPECIFICATIONSCCL3924PRCCL3018PR CCL3924PRA CCL3930PRCCL3018PRA CHL3924PR CCL3930PRABtu (Variable) 16,000/30,000 20,000/3

www.desatech.com111161-01D 33REPLACEMENT PARTSNote: Use only original replacement parts. Thiswill protect your warranty coverage for parts re-placed u

www.desatech.com 111161-01D34ACCESSORIESPurchase these fireplace accessories from your lo-cal dealer. If they can not supply these accessories,either

www.desatech.com111161-01D 35_________________________________________________________________________________________________________________________

2701 Industrial DriveP.O. Box 90004Bowling Green, KY 42102-9004www.desatech.com111161-01Rev. D04/04NOT A UPCWARRANTY INFORMATIONKEEP THIS WARRANTYMode

www.desatech.com 111161-01D4SAFETY INFORMATIONContinued3. To prevent performance problems, the use ofa propane/LP fuel tank of less than 100 lb.capaci

www.desatech.com111161-01D 5PRODUCTIDENTIFICATIONFigure 1 - Vent-Free Gas Log Heater(Logs May Vary By Model)Log SetControlKnobBaseGratePiezoIgnitorOpt

www.desatech.com 111161-01D6AIR FOR COMBUSTIONAND VENTILATIONContinuedPROVIDING ADEQUATEVENTILATIONThe following are excerpts from National FuelGas Co

www.desatech.com111161-01D 7* Do not include direct-vent gas appliances. Di-rect-vent draws combustion air from the outdoorsand vents to the outdoors.

www.desatech.com 111161-01D8 WARNING: Seal any freshair vents or ash clean-out doorslocated on floor or wall of fire-place. If not, drafting may cause

www.desatech.com111161-01D 9INSTALLATIONContinued WARNING: This applianceis equipped for (natural or pro-pane/LP) gas. Field conversionis not permitte